Product ID:B & B 120-N
MSDS Date:04/04/1989
FSC:6850
NIIN:00-543-7801
MSDS Number: BJPLK

B AND B TRITECH CO INC.

875 W 20TH STREET
HIALENA, FL 33010-2310
US

Emergency Phone: 305-888-5247

Info Phone: 305-888-5247

Cage: LO016

B AND B TRITECH CO INC.

HIALENA, FL 33010-2310 US

Telephone: 305-888-5247

Cage: LO016

METHYLENE CHLORIDE (SARA III)

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL 500 PPM/C,1000; Z2

ACGIH TLV: 50 PPM, A2; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CRESOL, ALL ISOMERS (CRESYLIC ACID) (SARA III)

CAS: 1319-77-3

RTECS: GO5950000

OSHA PEL S, 5 PPM

ACGIH TLV: S, 5 PPM; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PHENOL

CAS: 108-95-2

RTECS: SJ3325000

OSHA PEL S, 5 PPM

ACGIH TLV: S, 5 PPM; 9091

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SODIUM CHROMATE (SARA III)

CAS: 7775-11-3

RTECS: GB2955000

OSHA PEL 0.1 PPM CRO3;CEILING

ACGIH TLV: 0.05 MG CR/M3; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PRODUCT CONTAINS CHEMICALS WHICH ARE
CORROSIVE TO BODY TISSUES. IT ALSO CONTAINS ORGANICS WHICH WILL
DEPRESS THE CENTRAL NERVOUS SYSTEM AND MAY DAMAGE THE LIVER AND/OR
KIDNEYS.
Explanation of Carcinogenicity:SODIUM CHROMATE AND DICHLOROMETHANE ARE
LISTED AS CARCINOGENS. SEE INDIVIDUAL REPORTS FOR DETAILS.
Effects of Overexposure:EYE:BURNS, POSSIBLE PERMINENT DAMAGE.
SKIN:CONTACT CAUSES DISCOLORATION AND IN A SHORT TIME BURNS AND/OR
SYSTEMIC POISONING. INHALED:DIZZINESS,HEADACHE,CENTRAL NERVOUS
SYSTEM DEPRESSION,LIVER/KIDNEY D AMAGE,CARDIOVASCULAR STRESS.
INGESTED:G/I BURNS, LIVER/KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:NONE GIVEN BY MANUFACTURER
(SUPPLIER).

First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY. INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.

Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF TOXIC & ACIDIC DECOMPOSITION PRODUCTS.

Spill Release Procedures:AVOID OPEN FLAMES. USE APPROPRIATE PROTECTIVE
EQUIPMENT. ADSORB WITH INERT MATERIAL.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP 4 INCH
FLOATING SEAL ON ACTIVE LAYER TO SLOW EVAPORAT
Other Precautions:DO NOT USE IN CONFINED SPACES.

Respiratory Protection:RESPIRATOR WILL USUALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ORGANIC MIST/VAPORS WHEN EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR
1910.134 FOR REGULATIONS PER TAINING TO RESPIRATOR USE.
Ventilation:GENERAL ROOM VENTILATION MAY BE ADEQUATE. EXPECT TO USE
LOCAL EXHAUST TO CONTROL EXPOSURE BELOW PEL/TLV.
Protective Gloves:NEOPRENE, NITRILE, VPC OR NATURAL RUBBER
Eye Protection:FULL FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. FULL
CHEMICAL SUIT WITH BOOTS. (EQUIPMENT MAY VARY DEPENDING ON ACTUAL
USEAGD.)
Work Hygienic Practices:USE STRICT CHEMICAL HYGIENE PRACTICE. AVOID ALL
CONTACT WHENEVER POSSIBLE.
Supplemental Safety and Health
MSDS WAS RECEIVED FROM NAVY. PRODUCT IS ON QPL BUT AS OF 1MAR91, THERE
IS NO EVIDENCE THAT THIS PRODUCT WAS EVER PURCHASED BY DLA.

HCC:C2
Spec Gravity:1.17
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:PARTIAL
Appearance and Odor:TWO PHASE LIQUID, CHLORINATED SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
ALKALIS AND STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE GIVEN BY MANUFACTURER (SUPPLIER).
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND A SMALL AMOUNT
OF PHOSGENE

Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER MAKES NO SUGGESTIONS FOR DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.